Solar vehicle


A solar vehicle is an electric vehicle powered completely or significantly by direct solar energy. Usually, photovoltaic cells contained in solar panels convert the sun's energy directly into electric energy. The term "solar vehicle" usually implies that solar energy is used to power all or part of a vehicle's propulsion. Solar power may be also used to provide power for communications or controls or other auxiliary functions.
Solar vehicles are not sold as practical day-to-day transportation devices at present, but are primarily demonstration vehicles and engineering exercises, often sponsored by government agencies. However, indirectly solar-charged vehicles are widespread and solar boats are available commercially.

Land

Solar cars

Solar cars depend on PV cells to convert sunlight into electricity to drive electric motors. Unlike solar thermal energy which converts solar energy to heat, PV cells directly convert the sun into electricity. For example, the recently launched Hyundai Solar Car, which has solar panels mounted on the rooftop of the car. The PV panels on the car would generate electricity to charge the batteries in the car.
The design of a solar car is severely limited by the amount of energy input into the car. Solar cars are built for solar car races and also for public use List of prototype solar-powered cars. Even the best solar cells can only collect limited power and energy over the area of a car's surface. This limits solar cars to ultralight composite bodies to save weight. Solar cars lack the safety and convenience features of conventional vehicles. The first solar family car was built in 2013 by students in the Netherlands. This vehicle is capable of 550 miles on one charge during sunlight. It weighs 850 pounds and has a 1.5kw solar array. Solar vehicles must be light and efficient. 3,000 pound or even 2,000 pound vehicles are less practical. Stella Lux, the predecessor to Stella, broke a record with a 932 mile single charge range. The Dutch are trying to commercialize this technology. During racing Stella Lux is capable of 700 miles during daylight. At 45 mph Stella Lux has infinite range. This is again due to high efficiency including a Coefficient of drag of.16. The average family who never drive more than 200 miles a day would never need to charge from the mains. They would only plug in if they wanted to return energy to the grid.
Solar cars are often fitted with gauges and/or wireless telemetry, to carefully monitor the car's energy consumption, solar energy capture and other parameters. Wireless telemetry is typically preferred as it frees the driver to concentrate on driving, which can be dangerous in such a small, lightweight car. The Solar Electric Vehicle system was designed and engineered as an easy to install integrated accessory system with a custom molded low profile solar module, supplemental battery pack and a proven charge controlling system.
As an alternative, a battery-powered electric vehicle may use a solar array to recharge; the array may be connected to the general electrical distribution grid.

Solar buses

Solar buses are propulsed by solar energy, all or part of which is collected from stationary solar panel installations. The Tindo bus is a 100% solar bus that operates as free public transport service in Adelaide City as an initiative of the City Council. Bus services which use electric buses that are partially powered by solar panels installed on the bus roof, intended to reduce energy consumption and to prolong the life cycle of the rechargeable battery of the electric bus, have been put in place in China.
Solar buses are to be distinguished from conventional buses in which electric functions of the bus such as lighting, heating or air-conditioning, but not the propulsion itself, are fed by solar energy. Such systems are more widespread as they allow bus companies to meet specific regulations, for example the anti-idling laws that are in force in several of the US states, and can be retrofitted to existing vehicle batteries without changing the conventional engine.

Single-track vehicles

The first solar "cars" were actually tricycles or Quadracycles built with bicycle technology. These were called solarmobiles at the first solar race, the Tour de Sol in Switzerland in 1985. With 72 participants, half used solar power exclusively while the other half used solar-human-powered hybrids. A few true solar bicycles were built, either with a large solar roof, a small rear panel, or a trailer with a solar panel. Later more practical solar bicycles were built with foldable panels to be set up only during parking. Even later the panels were left at home, feeding into the electric mains, and the bicycles charged from the mains. Today highly developed electric bicycles are available and these use so little power that it costs little to buy the equivalent amount of solar electricity. The "solar" has evolved from actual hardware to an indirect accounting system. The same system also works for electric motorcycles, which were also first developed for the Tour de Sol.

Applications

The Venturi Astrolab in 2006 was the world's first commercial electro-solar hybrid car, and was originally due to be released in January 2008.
In May 2007 a partnership of Canadian companies led by Hymotion altered a Toyota Prius to use solar cells to generate up to 240 watts of electrical power in full sunshine. This is reported as permitting up to 15 km extra range on a sunny summer day while using only the electric motors.
An inventor from Michigan, USA built a street legal, licensed, insured, solar charged electric scooter in 2005. It had a top speed controlled at a bit over 30 mph, and used fold-out solar panels to charge the batteries while parked.

Auxiliary power

Photovoltaic modules are used commercially as auxiliary power units on passenger cars in order to ventilate the car, reducing the temperature of the passenger compartment while it is parked in the sun. Vehicles such as the 2010 Prius, Aptera 2, Audi A8, and Mazda 929 have had solar sunroof options for ventilation purposes.
The area of photovoltaic modules required to power a car with conventional design is too large to be carried on board. A prototype car and trailer has been built . According to the website, it is capable of 100 km/day using 6m2 of standard crystalline silicon cells. Electricity is stored using a nickel/salt battery. A stationary system such as a rooftop solar panel, however, can be used to charge conventional electric vehicles.
It is also possible to use solar panels to extend the range of a hybrid or electric car, as incorporated in the Fisker Karma, available as an option on the Chevy Volt, on the hood and roof of "Destiny 2000" modifications of Pontiac Fieros, Italdesign Quaranta, Free Drive EV Solar Bug, and numerous other electric vehicles, both concept and production. In May 2007 a partnership of Canadian companies led by Hymotion added PV cells to a Toyota Prius to extend the range. claims 20 miles per day from their combined 215W module mounted on the car roof and an additional 3kWh battery.
On 9 June 2008, the German and French Presidents announced a plan to offer a credit of 6-8g/km of CO2 emissions for cars fitted with technologies "not yet taken into consideration during the standard measuring cycle of the emissions of a car". This has given rise to speculation that photovoltaic panels might be widely adopted on autos in the near future
It is also technically possible to use photovoltaic technology, to provide motive power for a car. Fuel is used to heat an emitter. The infrared radiation generated is converted to electricity by a low band gap PV cell. A prototype TPV hybrid car was even built. The "Viking 29" was the World’s first thermophotovoltaic powered automobile, designed and built by the Vehicle Research Institute at Western Washington University. Efficiency would need to be increased and cost decreased to make TPV competitive with fuel cells or internal combustion engines.

Personal rapid transit

Several personal rapid transit concepts incorporate photovoltaic panels.

Rail

Railways presents a low rolling resistance option that would be beneficial for planned journeys and stops. PV panels were tested as APUs on Italian rolling stock under EU project.. Direct feed to a DC grids avoids losses through DC to AC conversion. DC grids are only to be found in electric powered transport: railways, trams and trolleybuses. Conversion of DC from PV panels to grid alternating current was estimated to cause around 3% of the electricity being wasted.
PVTrain concluded that the most interest for PV in rail transport was on freight cars where on board electrical power would allow new functionality:
The Kismaros – Királyrét narrow-gauge line near Budapest has built a solar powered railcar called 'Vili'. With a maximum speed of 25 km/h, 'Vili' is driven by two 7 kW motors capable of regenerative braking and powered by 9.9m2 of PV panels. Electricity is stored in on-board batteries. In addition to on-board solar panels, there is the possibility to use stationary panels to generate electricity specifically for use in transport.
A few pilot projects have also been built in the framework of the "Heliotram" project, such as the tram depots in Hannover Leinhausen and Geneva. The 150 kWp Geneva site injected 600 V DC directly into the tram/trolleybus electricity network provided about 1% of the electricity used by the Geneva transport network at its opening in 1999. On December 16, 2017 a fully solar-powered train was launched in New South Wales, Australia. The train is powered using onboard solar panels and onboard rechargeable batteries. It holds a capacity for 100 seated passenger for a 3 km journey.
Recently Imperial College London and the environmental charity have announced the Renewable Traction Power project to investigate using track-side solar panels to power trains. Meanwhile, Indian railways announced their intention to use on board PV to run air conditioning systems in railway coaches. Also, Indian Railways announced it is to conduct a trial run by the end of May 2016. It hopes that an average of 90,800 liters of diesel per train will be saved on an annual basis, which in turn results in reduction of 239 tonnes of CO2.

Water

Solar powered boats have mainly been limited to rivers and canals, but in 2007 an experimental 14m catamaran, the Sun21 sailed the Atlantic from Seville to Miami, and from there to New York. It was the first crossing of the Atlantic powered only by solar.
Japan's biggest shipping line Nippon Yusen KK and Nippon Oil Corporation said solar panels capable of generating 40 kilowatts of electricity would be placed on top of a 60,213 ton car carrier ship to be used by Toyota Motor Corporation.
In 2010, the Tûranor PlanetSolar, a 30 metre long, 15.2 metre wide catamaran yacht powered by 470 square metres of solar panels, was unveiled. It is, so far, the largest solar-powered boat ever built. In 2012, PlanetSolar became the first ever solar electric vehicle to circumnavigate the globe.
Various demonstration systems have been made. Curiously, none yet takes advantage of the huge power gain that water cooling would bring.
The low power density of current solar panels limits the use of solar propelled vessels, however boats that use sails rely on battery power for electrical appliances. Here solar panels have become popular for recharging batteries as they do not create noise, require fuel and often can be seamlessly added to existing deck space.

Air

Solar ships can refer to solar powered airships or hybrid airships.
There is considerable military interest in unmanned aerial vehicles ; solar power would enable these to stay aloft for months, becoming a much cheaper means of doing some tasks done today by satellites. In September 2007, the first successful flight for 48h under constant power of a UAV was reported.
This is likely to be the first commercial use for photovoltaics in flight.
Many demonstration solar aircraft have been built, some of the best known by AeroVironment.

Manned solar aircraft

Unmanned aerial vehicles

Solar powered spacecraft

Solar energy is often used to supply power for satellites and spacecraft operating in the inner solar system since it can supply energy for a long time without excess fuel mass. A Communications satellite contains multiple radio transmitters which operate continually during its life. It would be uneconomic to operate such a vehicle from primary batteries or fuel cells, and refuelling in orbit is not practical. Solar power is not generally used to adjust the satellite's position, however, and the useful life of a communications satellite will be limited by the on-board station-keeping fuel supply.

Solar propelled spacecraft

A few spacecraft operating within the orbit of Mars have used solar power as an energy source for their propulsion system.
All current solar powered spacecraft use solar panels in conjunction with electric propulsion, typically ion drives as this gives a very high exhaust velocity, and reduces the propellant over that of a rocket by more than a factor of ten. Since propellant is usually the biggest mass on many spacecraft, this reduces launch costs.
Other proposals for solar spacecraft include solar thermal heating of propellant, typically hydrogen or sometimes water is proposed. An electrodynamic tether can be used to change a satellite's orientation or adjust its orbit.
Another concept for solar propulsion in space is the light sail; this doesn't require conversion of light to electrical energy, instead relying directly on the tiny but persistent radiation pressure of light.

Planetary exploration

Perhaps the most successful solar-propelled vehicles have been the "rovers" used to explore surfaces of the Moon and Mars. The 1977 Lunokhod programme and the 1997 Mars Pathfinder used solar power to propel remote controlled vehicles. The operating life of these rovers far exceeded the limits of endurance that would have been imposed, had they been operated on conventional fuels.

Electric vehicle with solar assist

A Swiss project, called "Solartaxi", has circumnavigated the world. This is the first time in history an electric vehicle has gone around the world, covering 50000 km in 18 months and crossing 40 countries. It is a road-worthy electric vehicle hauling a trailer with solar panels, carrying a 6 m² sized solar array. The Solartaxi has Zebra batteries, which permit a range of 400 km without recharging. The car can also run for 200 km without the trailer. Its maximum speed is 90 km/h. The car weighs 500 kg and the trailer weighs 200 kg. According to initiator and tour director Louis Palmer, the car in mass production could be produced for 16000 Euro. Solartaxi has toured the World from July 2007 till December 2008 to show that solutions to stop global warming are available and to encourage people in pursuing alternatives to fossil fuel. Palmer suggests the most economical location for solar panels for an electric car is on building rooftops though, likening it to putting money into a bank in one location and withdrawing it in another.
Solar Electrical Vehicles is adding convex solar cells to the roof of hybrid electric vehicles.

Plug-in hybrid and solar vehicles

An interesting variant of the electric vehicle is the triple hybrid vehicle—the PHEV that has solar panels as well to assist.
The 2010 Toyota Prius model has an option to mount solar panels on the roof. They power a ventilation system while parked to help provide cooling. There are many applications of photovoltaics in transport either for motive power or as auxiliary power units, particularly where fuel, maintenance, emissions or noise requirements preclude internal combustion engines or fuel cells. Due to the limited area available on each vehicle either speed or range or both are limited when used for motive power.

Limitations

There are limits to using photovoltaic cells for vehicles: